3 and a half years ago I purchased a 2002 Pajero 3.2 DID SWB GLS, rooftop tent and all, with 253,000 kms on the clock. Today it is on 297,000 kms and we have had great times with it in Kgalagadi.
Over the last few months I have been experiencing radiator water loss. No leaks though. I had the radiator and a pipe replaced, and still water loss. And no obvious water drips. The engine did seem to get hot when the water was low, but I never let it hit red.
Further pressure tests indicated that there could be gasket problems, so I took it to Mitsubishi to investigate. After more than a month, and removing and sending the cylinder head away for analysis, the reply came back that the head was warped and could not be skimmed.
I was asked if I was sitting down, to which I replied "Yes!".
I was then told that the head needed replacing and the cost would be R84,000. The head alone was R44,000.
I only paid R125,000 for the vehicle.
Any constructive suggestions for me?
2015 3.2 DiD GLS SWB - Acquired Oct 2015 currently on 40,000kms
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
I am pretty sure you can get AMC heads for less than that. Maybe talk to an engineering shop. I had a full rebuild done on my old 2001 about 2 years ago for around R66000 but sadly it never was the same again.
CATS
Sent from my LG-H815 using Tapatalk
CATS
Sent from my LG-H815 using Tapatalk
2009 Pajero 3.2 DiDc Lwb GLS (Gen4) - Casper (Starting to grow on me)
2001 Pajero 3.2 DiD Lwb GLS Manual (Gen3) - Snoopy (SOLD but not forgotten)
2008 Pajero 3.2 DiDc Lwb GLS Auto (Gen4) - Silvester (SOLD)
2001 Pajero 3.2 DiD Lwb GLS Manual (Gen3) - Snoopy (SOLD but not forgotten)
2008 Pajero 3.2 DiDc Lwb GLS Auto (Gen4) - Silvester (SOLD)
I suggest you try the used parts outlets. I bought a replacement head for my Mark 1 at JAP Motor Spares in Kempton Park a few years ago. You will have to have it checked over - valves & guides etc but you may be able to use parts from your exisiting head.
1986 Mark 1 Pajero 2.5L turbo diesel station wagon
1993 220si Toyota Camry saloon auto
1993 220si Toyota Camry saloon auto
Components for Africa in Krugersdorp 011 660 6639 No where near as dear..
If you can feel the grass between your toe's, your flying too low!
3.5 GLS F/LIF 1998 Lost to the x wife
3200 Tdi GSL 2001 Written off
3200 Di-D 5Dr A/T 2002 338 000 Sold
3500i A/T 5Dr 2001 Sold
3.2 Di-Dc GLS A/T 2008
3.5 GLS F/LIF 1998 Lost to the x wife
3200 Tdi GSL 2001 Written off
3200 Di-D 5Dr A/T 2002 338 000 Sold
3500i A/T 5Dr 2001 Sold
3.2 Di-Dc GLS A/T 2008
Thanks Marty Russell and CATS for the comments.
2015 3.2 DiD GLS SWB - Acquired Oct 2015 currently on 40,000kms
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
And Lock, of course
Thanks
Thanks
2015 3.2 DiD GLS SWB - Acquired Oct 2015 currently on 40,000kms
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
Been there done that!
I see that you are in CPT. There is an Engineering shop in Bellville. He has new heads in stock for the Gen 3 DID. R7000 last time I checked. Tygerberg Engine rebuilders uses his heads as well if you want to inquire.
If you don't come right, let me know, I'll search through my archives. Should still have his details SOMEWHERE.
I see that you are in CPT. There is an Engineering shop in Bellville. He has new heads in stock for the Gen 3 DID. R7000 last time I checked. Tygerberg Engine rebuilders uses his heads as well if you want to inquire.
If you don't come right, let me know, I'll search through my archives. Should still have his details SOMEWHERE.
Hi sixmaniac
Thanks for the Tygerberg Engine Rebuilders tip.
I contacted them and they may be able to help.
Will let you know the outcome.
Glyn
Thanks for the Tygerberg Engine Rebuilders tip.
I contacted them and they may be able to help.
Will let you know the outcome.
Glyn
2015 3.2 DiD GLS SWB - Acquired Oct 2015 currently on 40,000kms
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
2002 3.2 DiD GLS SWB - Acquired Jan 2013 on 297,000kms (sold Dec 2016)
Hello C, I've got a extra cylinder head. My engineering shop made me buy a new one whilst the block was cracked. You can have it checked out first and fit it before you pay me if you are interested. I want R3000 for it. BUT you need to be happy and done about 5000 kilos's before you pay me. I stay in Standerton. 0826455081 Regards Casper
Gee Casper the deal you are giving Curly, is fantastic.Your are a genuin person.